I have tried brooding chicks in lots of things - plastic kiddie pools (they quickly learn to fly out) galvanized tubs (snakes can get in, don't ask!), cardboard boxes (they get wet and I worry about the fire hazard from the heat lamp) and finally settled on making my own brooder box out of a plastic storage tote. It's quick and easy to make, inexpensive, durable, 100% safe, easy to clean and reusable. Here's how to make one:
What you'll need:
Large covered opaque plastic storage tote (buy the largest you can find at Lowes, Walmart, etc)
Furring strip or other thin wooden board (approximately 8 feet long)
Piece of 1/2" hardware cloth
8 Nuts and bolts
Small nails and screws
What to do:
Cut a window in the lid of the tote, leaving a frame of about 2" all the way around with the box cutter. I drew the outline using a Sharpie and then scored the plastic first with the box cutter before trying to cut all the way through (don't worry, it doesn't have to be perfect). Using the wire cutters, trim the hardware cloth to a size about 1" larger than the window you just cut.
Using the jigsaw, cut four pieces of the furring strip to form a frame the same size at the hardware cloth, then pre-drill a hole in either end of each strip.
Sandwich the hardware cloth in between the tote cover and furring strips and then thread a bolt through each hole and secure with a nut using the screwdriver and pliers. Here's what your lid should look like on the underside:
And from the top, your lid will look like this:
Cut the dowel to make some miniature roosts (use small nails to attach the legs) and use small screws drilled through the side of the tote into the ends of each dowel to secure them in place.
Newspaper can be too slippery for little feet and can cause spraddle leg, so I use several layers of newsprint covered with a sheet of rubber shelf liner for a non-slip surface of the brooder. The shelf liner is easy to remove, rinse off and reuse.
Your chicks will need chick-sized feeders and waterers. Placing small stones or marbles in the waterer will ensure no unfortunate drownings. A small dish of chick-sized grit is necessary to help the chicks grind up and digest any food you feed them other than chick starter feed. Feed and water should be offered 24/7 for at least the first few weeks so the chicks can eat and drink as necessary. Treats such as cut grass, weeds or soft scrambled eggs or oatmeal can be introduced slowly.
A heat lamp (preferably with a red bulb) or Brinsea Eco Glow is needed to keep the brooder a toasty 95 degrees the first week and then 5 degrees cooler each subsequent week until the chicks are feathered out and the temperature is around 70 degrees, at which point they can be moved outside (if it's warm enough) or you can remove the heat and keep them in the house or garage for a bit longer if you live in a colder climate.
|-Buy your Brinsea EcoGlow here from amazon-|
Pine shavings or chips can be added to the floor of the brooder after the first several days once the chicks figure out what is food and what isn't (never use cedar shavings, which can be toxic). You can also use shredded paper, or shredded newsprint, straw or dry hat.
While you might have read it's okay and might be tempted because it seems easy, DO NOT use sand in your brooder. The chicks will eat it which can seriously deprive them of nutrients if they fill up on the sand and don't eat enough of their feed. Even worse, it can become sodden and stuck in their crops causing impacted crop which can kill them. When they poop in sand, the sand will 'bread' the poop and there's a good chance they'll eat that also which can be extremely detrimental to their health.
Your chicks will love their brooder. Placed in a quiet part of the house - we usually use our laundry room or guest bathroom - the chicks are safe from our curious cat and playful puppy. The opaque sides allow them to peer through the tote to get used to the big world outside their sanctuary.
I think the older hens somehow know what it means when the brooder comes out of the barn and gets dusted off!
|~"Uh-oh.....looks like more little ones will be here soon!"`|
The tote works for a handful of chicks best, any more and you might need to build them a duplex. To make the duplex, I merely cut a hole in the side of each of two totes and then connected them using a 'chunnel', a tunnel I made by cutting the top and bottom off a clear plastic container and then putting slit rubber tubing over the rough edges once I had pushed the container through the hole in each tote. I had a heat lamp set up over one tote and the Brinsea Eco-Glow in the other so the chicks were warm not matter which tote they were in.
For more on successfully brooding and raising chicks, as well as more photos of the brooder box set-up read HERE.
Join us on Facebook at Fresh Eggs Daily for more tips, tricks and cute photos!